FAQs

Q?

How long should a catalytic converter last?

A.

Catalysts often last 10 years, but actual life depends on mileage and engine tune. 50,000 miles is a more reasonable benchmark, and you can generally expect to replace the catalytic converter once during the life of a vehicle.

If failure occurs early, it's important to find and fix the cause of the problem before fitting a new CAT otherwise the replacement can be expected to fail prematurely too.

There are three main ways they fail:

  • Melt down - unburned fuel enters the catalyst and ignites on contact. The extreme heat literally melts the ceramic matrix. Poor ignition timing, a faulty oxygen sensor, worn or defective spark plugs, incorrect fuel mixture and other ignition/fuel injection related faults could lead to this failure.
  • Carbon deposits - oil or antifreeze entering the combustion chamber/exhaust system can lead to a build up of carbon on the matrix, which increases back pressure leading to overheating and poor performance.
  • Catalyst fracture - the ceramic matrix is fragile and can break-up as a result of excessive vibration or external impact. As the matrix breaks up back-pressure increases and overheating can result.

Q?

Must I get air conditioning serviced?

A.

Regular servicing is important for health and to maintain the system working effectively. Up to 15% of the refrigerant gas will be lost annually.

  • Run your air conditioning at least once a week throughout the year.
  • Have the refrigerant gas checked regularly and topped up to manufacturers' recommended levels.
  • Help improve hygiene and air quality with a regular cabin filter change, as it can become blocked with pollen.
  • A regular air duct clean helps remove the bacteria and fungi that can cause unpleasant odours.
  • Service air-conditioning units every 30,000 miles or two years to avoid costly repairs.

Q?

What are the advantages of synthetic oils?

A.

Synthetics and semi-synthetics give improved performance at high temperatures and support extended standard drain intervals. They are the preferred choice for high perfomance cars or for drivers who value long life/durability.

  • Your vehicle handbook will specify the grade/type of oil to be used based on durability/extreme environment testing by the manufacturer.
  • If synthetic oils are recommended then that is what you should use.
  • Mixing mineral and synthetics is not recommended, nor is switching to synthetic oils unless the vehicle handbook specifies that you may do so.

If the manufacturer has confirmed that synthetic oil is suitable for your vehicle and you intend to switch then you must make sure that the engine is drained fully of mineral oil first.

Q?

When should the cambelt be renewed?

A.

There's not a standard change interval for cambelts.

  • Depending on the model and the manufacturer, the recommended interval can be anywhere between 30,000 miles and 100,000 miles. There will often be a time-based interval specified too e.g. 60,000 miles or five years, whichever is the sooner.
  • Sometimes the manufacturer will revise the recommended interval during the life of the vehicle so it's best to check with a franchise dealer as they will have the most up-to-date information. They will need to know the make, model, engine number and model year.
  • In most cases cambelt failure results in serious damage to many other components in the engine - a major rebuild or even replacement engine will be required!

It does no harm to renew the belt early. If you buy a used car it's wise to get the belt renewed if you are in any doubt that it has been renewed at the appropriate time.

Q?

Airbag renewal after 10 years. What should I do?

A.

When cars were first fitted with airbags there was a lack of knowledge and confidence about the long term reliabiilty of the systems . Car manufacturers and manufacturers of airbag systems agreed to validate (or test) them for a 10 year life span.

A sodium azide tablet produces the gas which inflates the airbag, and this tablet and the explosive device are sealed. Although some moisture ingress is possible it should not affect performance. There will also be some natural chemical decay, but again this shouldn't stop the airbag from working.

There was also some concern in the early days that the airbag cover could become brittle through aging and a flying fragment cause eye damage.

Manufacturers increased the validation period to 15 years on later cars without making major changes to design and we are not aware of any airbag failures atttributed to ageing.

Q?

Do I have to get my car serviced by a main dealer?

A.

You are not obliged (since October 2003) to get the car serviced by a franchise dealer during the warranty period.

You must though get it serviced according to the manufacturer's recommended schedule and criteria using only manufacturer approved parts.

The legislation only applies to the part of the warranty offered by the manufacturer, i.e. insurance-backed extended warranties offered by dealers are not covered and may stipulate different conditions.

If you do get the car serviced outside the dealer networkyou must make sure it's done to the maker's recommended schedule and criteria using approved parts. You must also keep records so you can demonstrate to the manufacturer that servicing was undertaken to their requirements.

You should still get warranty work undertaken by the franchised dealer as it is easier for them to deal directly with the manufacturer.

Read about repairs after the warranty expires before deciding to go outside the dealer network for servicing during the warranty.

Q?

Why isn’t clutch failure covered by the warranty?

A.

Clutch life can be seriously affected by poor driving style:

  • Resting a foot on the pedal (riding the clutch)
  • Holding the car on the clutch on hills rather than using the handbrake, or
  • Letting the clutch slip excessively

If the garage has repaired the car, but say the failure has been caused by driver abuse, then ask them for the old components and get a second opinion from another garage or mechanic. The garage is entitled to ask you to pay for the work before allowing you to take your car.

If one of the components has broken and caused the failure, then you may be able to claim under the warranty. Regrettably, if there is no evidence of manufacturing or material defect, you will have to pay for the new clutch and cost of fitting.